↓ Advertise on Defender2 ↓

Home > Maintenance & Modifications > Waterproofing sealant choice
Post Reply  Down to end
Page 1 of 1
Print this entire topic · 
Yorkshire90



Member Since: 22 Sep 2011
Location: West Yorkshire
Posts: 203
United Kingdom 
Waterproofing sealant choice
Done a fair bit of searching on the forums before posting. Found a few brand names and sealants for decision.

Can see daylight through a few places on my defender hard top. The seal between the hard top and tub looks a bit worse for wear so going to give it a good seal all round, inside and out, even in the tub bottom... might as well.

Will be looking for a black coloured sealant. Which would you buy out of these two I've found from this forum:

Sikaflex 291 Fast Cure Marine Adhesive Sealant - BLACK

www.ebay.co.uk/itm/Sikaflex-291-Fast-Cure-...317wt_1039

Or one of the Siroflex range super adhesive range

SX MIGHTY STRENGTH MS POLYMER ADHESIVE & SEALANT

www.siroflex.co.uk/sections/SXrange/MSadhesives_sealants.html

Siroflex not far from my Grans for a shopping run too. Thumbs Up

Thanks for your thoughts. Very Happy
Post #153300 2nd Jul 2012 7:30pm
View user's profile Send private message View poster's gallery Reply with quote
bob neville



Member Since: 30 Apr 2009
Location: Marbella
Posts: 3248
Spain 2001 Defender 90 Td5 SW Epsom Green
Siroflex Thumbs Up

Just had two tubes delivered to do the join between the HT and tub on the 90.

Have a read.

http://www.defender2.net/forum/topic12247.html?highlight=siroflex

Bob 2015 Jaguar XE240 R Sport - goes like ....... !!
2013 Defender 90 CSW - sold
2009 Defender 110 Double Cab - sold
2001 TD5 90 CSW - offroad project - sold to a forum member
2011 Porsche Boxster - for the sunny days !
Post #153303 2nd Jul 2012 7:41pm
View user's profile Send private message View poster's gallery Reply with quote
Yorkshire90



Member Since: 22 Sep 2011
Location: West Yorkshire
Posts: 203
United Kingdom 
Cheers Bob, yours does look like a smart job and was one where I found the brand name.

How quickly does it set?

It's Chawton white so if I prepare it right, there shouldn't be any overflow etc.

Plus if I prep like you did with the masking tape. How deep did you apply the tape as to avoid messing up the job when removing it?

Will 4 tubes be enough for inside and out do you think?

How much per tube?

Thanks again. James
Post #153306 2nd Jul 2012 7:45pm
View user's profile Send private message View poster's gallery Reply with quote
bob neville



Member Since: 30 Apr 2009
Location: Marbella
Posts: 3248
Spain 2001 Defender 90 Td5 SW Epsom Green
Hi James

That one is not mine just the thread I saw about the product and decided to try.

PM the original poster as I am sure he will answer all your questions Thumbs Up

I purchased two tubes, it is a pain to find in black but probably easier to find in white.

Edit - this is where I got mine from after lots of searching.

http://www.transtools.co.uk/store/prod_830...white.html

Bob 2015 Jaguar XE240 R Sport - goes like ....... !!
2013 Defender 90 CSW - sold
2009 Defender 110 Double Cab - sold
2001 TD5 90 CSW - offroad project - sold to a forum member
2011 Porsche Boxster - for the sunny days !
Post #153309 2nd Jul 2012 7:58pm
View user's profile Send private message View poster's gallery Reply with quote
K9F



Member Since: 12 Nov 2009
Location: Bournemouth
Posts: 9610
United Kingdom 2008 Defender 90 Puma 2.4 XS CSW Stornoway Grey
Can't comment on the Siroflex range as I have never used it. I can however not recommend highly enough Sikaflex. It is used prolifically through the marine industry above and below the waterline. 'Marine' is for me the keyword in the sales pitch.....If it can withstand the rigours of a sea salt water environment it will more than sufficient for use on a Defender.

Try one brand, if it's rubbish strip off and try the other. I personally would start with the Sikaflex, I've used it lots on the Defender....

Whistle If you go through life with your head in the sand....all people will see is an ar5e!!

Treat every day as if it is your last....one day you will be right!!

Last edited by K9F on 2nd Jul 2012 8:23pm. Edited 1 time in total
Post #153313 2nd Jul 2012 8:16pm
View user's profile Send private message View poster's gallery Reply with quote
Yorkshire90



Member Since: 22 Sep 2011
Location: West Yorkshire
Posts: 203
United Kingdom 
Duh! Sorry Thumbs Up

Cheers Bob!
Post #153314 2nd Jul 2012 8:17pm
View user's profile Send private message View poster's gallery Reply with quote
landy andy



Member Since: 15 Feb 2009
Location: Ware, Herts
Posts: 5899
2006 Defender 110 Td5 USW Zermatt Silver
Done my joint of tub to hard top with sikaflex Thumbs Up Thumbs Up

Top job, and good stuff

Andy
Post #153315 2nd Jul 2012 8:18pm
View user's profile Send private message View poster's gallery Reply with quote
ginjez



Member Since: 18 Sep 2011
Location: huddersfield
Posts: 1769
2011 Defender 90 Puma 2.4 ST Santorini Black
Siroflex mighty strength is great. Widely available in Brighouse and Barnsley which is not too far from Casvegas. Alternatively have a ride over to Holmfirth and I'll do the job for you Thumbs Up
Post #153316 2nd Jul 2012 8:19pm
View user's profile Send private message View poster's gallery Reply with quote
Yorkshire90



Member Since: 22 Sep 2011
Location: West Yorkshire
Posts: 203
United Kingdom 
ginjez wrote:
Siroflex mighty strength is great. Widely available in Brighouse and Barnsley which is not too far from Casvegas. Alternatively have a ride over to Holmfirth and I'll do the job for you Thumbs Up


Thanks for the offer Very Happy Us CasVegasites aren't usually allowed out of the cave. I've emailed Siroflex for nearest stockist Thumbs Up

I reckon both products will do a quality job. It's just which is the easiest to get a hold of.

Thanks for your input everyone.
Post #153346 2nd Jul 2012 11:03pm
View user's profile Send private message View poster's gallery Reply with quote
custom90



Member Since: 21 Jan 2010
Location: South West, England.
Posts: 20795
United Kingdom 
K9F wrote:
Can't comment on the Siroflex range as I have never used it. I can however not recommend highly enough Sikaflex. It is used prolifically through the marine industry above and below the waterline. 'Marine' is for me the keyword in the sales pitch.....If it can withstand the rigours of a sea salt water environment it will more than sufficient for use on a Defender.

Try one brand, if it's rubbish strip off and try the other. I personally would start with the Sikaflex, I've used it lots on the Defender....

Whistle

I was waiting for the Sikaflex announcement Thumbs Up _\Hennessey|Venom| F5/___
___\⭐️Lone|Star|State/___
____\We|Will|Win/___
____/🇬🇧🇺🇸\____
_//*⛽️🛢️⚙️🧰*\\_
Post #153347 2nd Jul 2012 11:05pm
View user's profile Send private message View poster's gallery Reply with quote
Yorkshire90



Member Since: 22 Sep 2011
Location: West Yorkshire
Posts: 203
United Kingdom 
custom90steve wrote:
K9F wrote:
Can't comment on the Siroflex range as I have never used it. I can however not recommend highly enough Sikaflex. It is used prolifically through the marine industry above and below the waterline. 'Marine' is for me the keyword in the sales pitch.....If it can withstand the rigours of a sea salt water environment it will more than sufficient for use on a Defender.

Try one brand, if it's rubbish strip off and try the other. I personally would start with the Sikaflex, I've used it lots on the Defender....

Whistle

I was waiting for the Sikaflex announcement Thumbs Up


Agh! Apologies K9F... I've been reading replies via email updates and totally missed out your comment. Sorry.

I did notice that the Sikaflex is triple the price of the Siroflex... perhaps this is for a reason?

Either way, ginjez job with the SX Mighty strength does look a pukka job.

Tough one... It is something that you want to do once and hopefully forget. Especially when you're getting the headlining out too and giving everything a good once over...
Post #153350 2nd Jul 2012 11:17pm
View user's profile Send private message View poster's gallery Reply with quote
K9F



Member Since: 12 Nov 2009
Location: Bournemouth
Posts: 9610
United Kingdom 2008 Defender 90 Puma 2.4 XS CSW Stornoway Grey
If you have problems sourcing you favoured Siroflex 'pm' me and I may be able to 'acquire' the odd tube of the much superior and 'not necessarily triple the price' Sikaflex.

Rolling with laughter Thumbs Up Rolling with laughter If you go through life with your head in the sand....all people will see is an ar5e!!

Treat every day as if it is your last....one day you will be right!!
Post #153361 3rd Jul 2012 6:02am
View user's profile Send private message View poster's gallery Post Reply
Post Reply  Back to top
Page 1 of 1
All times are GMT + 1 Hour

Jump to  
<  Previous Topic | Next Topic >
Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum



Site Copyright © 2006-2025 Futuranet Ltd & Martin Lewis
DEFENDER2.NET RSS Feed - All Forums